Tell us about the job
Takes about a minute. No obligation.
Sizing a furnace correctly for this house is the decision a contractor has to settle before anything else goes on the quote. Homes in Hodgeman County, KS run heat about seven months a year, from October through April. The burner and heat exchanger carry that load month after month, and a unit that is undersized runs longer cycles to meet the thermostat, which accelerates wear on the ignition system and the heat exchanger itself. An installer who skips a proper load calculation and drops in a box that looks adequate on paper is handing the homeowner a furnace that will show fatigue sooner than the equipment was rated for.
Ductwork sized and routed for an old gravity furnace does not move air the way a modern forced-air system needs it to. A contractor installing a new furnace here has to assess what the existing trunk lines will actually carry before anything else gets priced, because a system that outpaces the ductwork delivers uneven heat and runs harder than it should. Half the homes in Hodgeman County, Kansas were built in 1957 or earlier (2020-2024 ACS 5-year). That gap between what the house was built around and what runs in it now is what makes the duct assessment the first real decision on the job, ahead of equipment selection.
What Gets Installed With a New Furnace
The furnace itself sits in a mechanical room, basement, or utility closet, and it is the unit a homeowner would see first when the work is done. Inside it, a heat exchanger and a blower work together: the exchanger warms the air, and the blower pushes that air out into the house. A flue pipe exits the unit and runs to an exterior wall or up through the roof to carry combustion gases out.
A thermostat mounts on a wall in the living space and is the control point for the whole system. Alongside the furnace, a contractor installs a gas line connection and a condensate drain line where the equipment requires one. A filter housing seats at the air intake, which is where return air enters the furnace before it reaches the heat exchanger.
The drawing shows a general layout of these components, and a licensed contractor determines exactly what applies to your house.
Get matched in Hodgeman CountyHodgeman County, by the numbers
161 severe weather events were recorded in Hodgeman County, Kansas between 2015 and 2024.
NOAA National Centers for Environmental Information, Storm Events Database, bulk CSV export, events 2015-01-01 through 2024-12-31.Half the homes in Hodgeman County, Kansas were built in 1957 or earlier (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesHodgeman County, Kansas holds 823 housing units (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesOwners occupy 79.1% of the occupied homes in Hodgeman County, Kansas (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesFurnace Installation Rules for Hodgeman County, Kansas4 codes and standards
What the Installation Actually Looks Like
Non-weatherized gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized oil-fired furnaces manufactured on or after November 19, 2015 must reach 83.0 percent AFUE.
Mobile home gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized gas furnaces manufactured on or after December 18, 2028 must reach 95.0 percent AFUE, up from the 80.0 percent minimum that applies to units manufactured before that date.
Severe Weather Events in Hodgeman County
Kansas weather puts real demands on heating equipment, and Hodgeman County is no exception to that pressure. A furnace sized and installed for local conditions handles those demands better than one that was not.
161 severe weather events, 2015–2024. Source: NOAA National Centers for Environmental Information, Storm Events Database.