Tell us about the job
Takes about a minute. No obligation.
Get the sizing wrong on a furnace here and the burner and heat exchanger carry that mistake for a long time. Homes in Ford County, KS run heat about seven months a year, from October through April. A contractor quoting a replacement has to run a proper load calculation for this house, not pull a number from the old unit's nameplate, because an undersized system cycles harder and an oversized one short-cycles, and either way the heat exchanger pays. The ignition system and the burner are the parts that take the most punishment across a season this long, and a quality install addresses how they are supported from day one.
Ductwork in much of this county was laid out for heating equipment that has since been replaced, and what it can carry is not a given. Half the homes in Ford County, Kansas were built in 1972 or earlier (2020-2024 ACS 5-year). That history matters most when a furnace goes in: a contractor measuring an existing duct run is checking whether the system can move the air a new unit delivers, and a run that falls short means the ductwork changes before the furnace does. The electrical side follows the same logic. Service panels in houses of this vintage were sized for loads that predate today's equipment, so a contractor checks available capacity before anything gets priced.
What Gets Installed With a New Furnace
The furnace itself sits in a utility space, basement, or dedicated mechanical room and is the heart of what a contractor places in the house. A heat exchanger lives inside that cabinet, and the blower motor beside it pushes conditioned air outward. The flue pipe runs from the furnace up and out of the house, carrying combustion gases away.
The thermostat mounts on an interior wall where it reads the air temperature of the living space and tells the furnace when to run. A contractor also sets the air filter housing at the furnace's intake and connects the gas line, which brings fuel from the home's supply to the burner assembly inside the cabinet.
The drawing shows a typical layout, and a licensed contractor determines exactly which components and configurations apply to your home.
Get matched in Ford CountyFord County, Kansas, by the numbers
484 severe weather events were recorded in Ford County, Kansas between 2015 and 2024.
NOAA National Centers for Environmental Information, Storm Events Database, bulk CSV export, events 2015-01-01 through 2024-12-31.Half the homes in Ford County, Kansas were built in 1972 or earlier (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesFord County, Kansas holds 12,743 housing units (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesOwners occupy 62.5% of the occupied homes in Ford County, Kansas (2020-2024 ACS 5-year).
U.S. Census Bureau, 2020-2024 American Community Survey 5-Year EstimatesFurnace Installation Rules for Ford County, Kansas4 sourced codes and standards
What the Installation Looks Like
Non-weatherized gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized oil-fired furnaces manufactured on or after November 19, 2015 must reach 83.0 percent AFUE.
Mobile home gas furnaces manufactured on or after November 19, 2015 must reach 80.0 percent AFUE.
Non-weatherized gas furnaces manufactured on or after December 18, 2028 must reach 95.0 percent AFUE, up from the 80.0 percent minimum that applies to units manufactured before that date.
Severe Weather History in Ford County
Ford County's climate puts real demands on heating equipment, and those demands vary year to year based on what the weather actually does. A furnace sized and installed for local conditions holds up better than one spec'd for somewhere else.
484 severe weather events, 2015–2024. Source: NOAA National Centers for Environmental Information, Storm Events Database.